SJVWC Forums

Please login or register.

Login with username, password and session length
Advanced search  
Pages: 1 2 3 4 [5] 6 7 8 ... 17   Go Down

Author Topic: Rich, your bus........  (Read 133797 times)

0 Members and 2 Guests are viewing this topic.

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #60 on: October 31, 2010, 05:16:16 pm »
Put on Glens' custom artwork today!

Logged

Baha (Shawn)

  • Club Vice President
  • PLATINUM Member
  • *****
  • Offline Offline
  • Gender: Male
  • Posts: 7340
  • SYNCRO HiTop----K2SMD
Re: Rich, your bus........
« Reply #61 on: October 31, 2010, 06:23:11 pm »
Beautiful Font... Very nice


And, it'll outlast the paint!
Logged
The VWs you can sleep in are more gooder

There are 3 kinds of people in this world, The kind that can count and the kind that can't.

scarecrow

  • Guest
Re: Rich, your bus........
« Reply #62 on: October 31, 2010, 06:43:08 pm »
Logged

lovebus (jack)

  • Club Co-Founder, Member SJVWCC
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 12473
  • Happy Trails Vanagon, AB2W
    • SJVWC Charter Member
Re: Rich, your bus........
« Reply #63 on: October 31, 2010, 10:09:06 pm »
from that angle it looks like Blue Balls.
Logged
I don't have to go to work in the morning....

RT 66 June 1, 2015

"Why restore it to its former short comings
When you can modify it too its full potential."

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #64 on: October 31, 2010, 10:21:58 pm »
Quote from: LoveBus (jack) on October 31, 2010, 10:09:06 pm
from that angle it looks like Blue Balls.
May be very accurate some days..:)
Logged

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #65 on: November 01, 2010, 04:29:14 pm »
Had a visit from Jack and Glen this morning,,, just a bit chilly, lucky I had my Kenmore dual purpose dryer and heater on..



After taking a look trying to get BlueBelle to life, Jack hooked positive jumper from his truck directly up to her starter. She cranked up...thinking we got a bad cable from battery, I went off to Pep Boys got a shiny new 6 gauge cable, installed, and replaced other ring terminals on starter post... coated with a bit of di grease, went to start it... got just about nothing... Thinking its now the battery, even though I had it charged...went back to Pep Boys, tested battery hoping it was crap, it passed fine...

Hmmmm... Now I'm drawing a diagram of wires...:(
Logged

matt

  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 4321
  • Member SJVWC
Re: Rich, your bus........
« Reply #66 on: November 04, 2010, 06:19:27 pm »


Using a voltmeter, did you get the right voltage to the starter when you turned the key?


 Matt

Logged
1955 3-fold semaphore Oval beetle
1971 Convertible beetle
1977 Westfalia, FI,  Berlin interior

Hard times create strong men. Strong men create good times. Good times create weak men. And, weak men create hard times.?
― G. Michael Hopf

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #67 on: November 04, 2010, 10:04:17 pm »
Quote from: matt on November 04, 2010, 06:19:27 pm

Using a voltmeter, did you get the right voltage to the starter when you turned the key?


 Matt



Thx Matt. I'm electrically challenged. Have no idea how to do that.

Update: Jack is pretty sure it's a crappy ground. So, I'm taking a few hours off friday am to:

- Polish down with a wire wheel to totally clean bare metal where battery ground is - On newer buses, there is a bolt into the sheet metal, right under where the "Brain" is , near the battery location.

I'm gonna start and see what happens.

- If that does nothing, I'm going to recheck the ground strap on the tranny nose cone.

Then start and see what happens

- If that does nothing, I'm running a second ground cable from the neg battery post to the engine block.

If that does nothing, I'm pushing it out of the driveway so I can go on the cruise saturday with the GlowBug.  Then, push it back in my Kenmore heated garage, and then try to wire in a starter relay. Jack gave directions on an earlier post a few months back to somebody.
Logged

lovebus (jack)

  • Club Co-Founder, Member SJVWCC
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 12473
  • Happy Trails Vanagon, AB2W
    • SJVWC Charter Member
Re: Rich, your bus........
« Reply #68 on: November 05, 2010, 07:54:14 am »
Make sure the ground strap on the Trans is going to the stud that the trans mount bolts to the body and not where the trans bolts to the mount.
Logged
I don't have to go to work in the morning....

RT 66 June 1, 2015

"Why restore it to its former short comings
When you can modify it too its full potential."

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #69 on: November 05, 2010, 01:31:28 pm »
 Ok,
Shined up body ground point with wire wheel, reconnected to battery, barely turns over.

Shined up engine block bolts, connected second ground cable to battery to one, then another, barely turns over.

Shined up the freakin connectors on the battery cable I'm using for second ground cable, barely turns over.

Thinkin I'm, smart, get out the remote starter, connect to starter/battery cable post and solenoid post, turn on power up at "key" to get fuel pump going, barely turns over.

Gotta go to work now... but my next steps are:

disconnect all wires on starter/solenoid other than directly to battery, and crank away.

also, double check tranny ground, although I have two grounds on the thing now anyway...

Nothing happens then, I'm disocnnecting the alternator wires from the positive battery cable.

At that point, I got nothing but a battery,solenoid, remote starter and a ground cranking on it...

I'll be going to the cruise saturday in my truck...



Logged

Daverted

  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1278
  • 74Sunbug,2020 Tiguan
Re: Rich, your bus........
« Reply #70 on: November 05, 2010, 01:43:43 pm »
Maybe...  the internal solenoid contact is overheated or corroded, Ive seen the melted inside if they get too hot, if Jack bypassed the solenoid and it turned over fast, Just maybe....   High Resistance in the solenoid ?
Logged

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #71 on: November 05, 2010, 01:52:25 pm »
Brand new starter/solnoid...replaced in July, along with the brnad spanking new battery, the brand new battery cables, the brand new terminal ends, the brand spankin new tranny ground strap...
  :)


Logged

rich67vw

  • Guest
Re: Rich, your bus........
« Reply #72 on: November 07, 2010, 10:43:37 am »
Got BlueBelle in nice somewhat heated garage... Gotta go to sleep after working 3rd shift last night.

I miss Tyler and Greg, my third shift chat buddies.

The suspense of getting her started will have to wait a bit...
Logged

lovebus (jack)

  • Club Co-Founder, Member SJVWCC
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 12473
  • Happy Trails Vanagon, AB2W
    • SJVWC Charter Member
Re: Rich, your bus........
« Reply #73 on: November 07, 2010, 12:28:03 pm »
Quote from: GlowBug (Rich) on November 07, 2010, 10:43:37 am

Got BlueBelle in nice somewhat heated garage...


somewhat heated is Really stretching that buddy (-;
Logged
I don't have to go to work in the morning....

RT 66 June 1, 2015

"Why restore it to its former short comings
When you can modify it too its full potential."

Evil-Tunes (Glen)

  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 992
    • Barnsboro 5pt Family Barbershop
Re: Rich, your bus........
« Reply #74 on: November 07, 2010, 05:57:31 pm »
Quote from: GlowBug (Rich) on November 07, 2010, 10:43:37 am
Got BlueBelle in nice somewhat heated garage

Quote from: LoveBus (jack) on November 07, 2010, 12:28:03 pm
somewhat heated is Really stretching that buddy (-;


Yea but you have to do A load of clothes to get some Heat


Cheers
 Glen
Logged
LifeTime Member
Pages: 1 2 3 4 [5] 6 7 8 ... 17   Go Up
« previous next »