SJVWC Forums

Please login or register.

Login with username, password and session length
Advanced search  
Pages: [1] 2   Go Down

Author Topic: Front firewall tin  (Read 17990 times)

0 Members and 3 Guests are viewing this topic.

rich67vw

  • Guest
Front firewall tin
« on: May 05, 2015, 08:38:05 am »
Can the front firewall tin be installed with the engine in the car? The PO never installed one as well as the rear engine seal and I'm thinking probably not a good thing as far as keeping the engine cool.  4thinking6

« Last Edit: May 05, 2015, 12:05:24 pm by MugMan (Rich) »
Logged

Bob(Herbie)

  • Bob(Herbie)
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1408
  • Herby
Re: front firewall tin
« Reply #1 on: May 05, 2015, 09:59:08 am »
Rich,
The front firewall tin can be installed with the engine in the car. But, it will be very tight on the drivers side if it is a dual port engine. The engine must be out to install the back engine seal. If you run the engine in hot weather without the tin and seals, the engine will over heat! The back seal prevents hot exhaust air from being pulled in the cooling fan. Without that seal the air keeps getting hotter and hotter!  old-\
Logged
46 years later and I am back to a '63 Rag named Herby
 '56 Oval Nigel  '53 Zwitter Project Stanley 
 Dalton said "Opinions Vary"

rich67vw

  • Guest
Re: Front firewall tin
« Reply #2 on: May 05, 2015, 12:13:06 pm »
Thx Bob.

Yep, I'm doing an inventory now of tins that I'm missing. Why do these PO's leave this stuff off after pulling the dang engine and the reinstall?  violent 
Just reinstall the same stuff you took off. For all I know, the flaps in the shroud are probably disconnected, missing, or stuck. I'll squish my hands in there tonight to see.

I'll just wait until when I have to yank the engine to install stuff the right way. In the meantime, I'll drive it as much as Daves' Sunbug so as to not damage it.  tongue\
Logged

rich67vw

  • Guest
Re: Front firewall tin
« Reply #3 on: May 05, 2015, 04:18:14 pm »
Bob  seems i could pull out the rear engine tin and pulley tin and get some of the new seal installed, no?
Logged

Bob(Herbie)

  • Bob(Herbie)
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1408
  • Herby
Re: Front firewall tin
« Reply #4 on: May 05, 2015, 07:53:13 pm »
Yes,
But the difficult part will be sliding the rubber seal into the side channels. I would use good quality food grade spray silicone or pine soap in a jar, if you can find it.  YoDa
Logged
46 years later and I am back to a '63 Rag named Herby
 '56 Oval Nigel  '53 Zwitter Project Stanley 
 Dalton said "Opinions Vary"

rich67vw

  • Guest
Re: Front firewall tin
« Reply #5 on: May 05, 2015, 08:23:13 pm »
thx bob  i might cut it in a few pieces and reglue once installed with weatherstrip adhesive  then sgain i might not bother since the front tin is missing 

may just wait since my clutch may be worn and telling me to replace it

 wa\ve
Logged

Bob(Herbie)

  • Bob(Herbie)
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1408
  • Herby
Re: Front firewall tin
« Reply #6 on: May 05, 2015, 08:59:44 pm »
The clutch job would be the time to do it all. It would save time on everything!
Logged
46 years later and I am back to a '63 Rag named Herby
 '56 Oval Nigel  '53 Zwitter Project Stanley 
 Dalton said "Opinions Vary"

Ant (Pop's Garage)

  • PLATINUM Member
  • ****
  • Offline Offline
  • Posts: 557
Re: Front firewall tin
« Reply #7 on: May 06, 2015, 08:43:41 am »
Yo get the stuff

Do a weekend over haul.

It's not like it's a vanagon or anything. Motor out by lunch back in by dinner.
Logged

lovebus (jack)

  • Club Co-Founder, Member SJVWCC
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 12473
  • Happy Trails Vanagon, AB2W
    • SJVWC Charter Member
Re: Front firewall tin
« Reply #8 on: May 06, 2015, 09:25:36 am »
What he said ^^^^^
Logged
I don't have to go to work in the morning....

RT 66 June 1, 2015

"Why restore it to its former short comings
When you can modify it too its full potential."

rich67vw

  • Guest
Re: Front firewall tin
« Reply #9 on: May 06, 2015, 10:30:16 am »
 idea\ Ordering stuff shortly.....
Logged

Baha (Shawn)

  • Club Vice President
  • PLATINUM Member
  • *****
  • Offline Offline
  • Gender: Male
  • Posts: 7340
  • SYNCRO HiTop----K2SMD
Re: Front firewall tin
« Reply #10 on: May 19, 2015, 10:24:28 pm »
Whats with the Vanagon hating? Block is the same as a Beetle.

And the nice part is you can lay on the bed and watch TV while while you pull the engine
Logged
The VWs you can sleep in are more gooder

There are 3 kinds of people in this world, The kind that can count and the kind that can't.

Ant (Pop's Garage)

  • PLATINUM Member
  • ****
  • Offline Offline
  • Posts: 557
Re: Front firewall tin
« Reply #11 on: May 19, 2015, 10:46:02 pm »
Not hate. U know removing a beetle motor vs a vanagon is way different.
Logged

6T5 square

  • PLATINUM Member
  • ****
  • Offline Offline
  • Posts: 5798
Re: Front firewall tin
« Reply #12 on: May 22, 2015, 05:35:58 am »
more plumbing
Logged
John
60 Beetle- Ned
65 1500S Squareback-Weezer gone but not forgotten
2014 Jetta
Dont know everything but I'll try and learn
Friends don't let friends drive 6 volts
Obnoxious objector??

Celly

  • Charter Member
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1057
  • SJVWC
Re: Front firewall tin
« Reply #13 on: May 22, 2015, 08:15:05 am »
Circles and Squares have been at odds since the Caveman    (argue\

 ^stirpot-
Logged
There are two things in ordinary conversation which ordinary people dislike - information and wit.

It\'s not a car, it\'s not a van, its a BUS!

Celly

  • Charter Member
  • PLATINUM Member
  • ****
  • Offline Offline
  • Gender: Male
  • Posts: 1057
  • SJVWC
Re: Front firewall tin
« Reply #14 on: May 22, 2015, 08:20:15 am »
Circle Caveman says "Circle good for wheel, mas rapido"

Square Caveman says "Square good for house, mas comodo"



Logged
There are two things in ordinary conversation which ordinary people dislike - information and wit.

It\'s not a car, it\'s not a van, its a BUS!
Pages: [1] 2   Go Up
« previous next »